use of ceramic waste powder in cement concrete
Welcome to Cina QC

use of ceramic waste powder in cement concrete.

Use of Ceramic Waste Powder in Cement Concrete

ceramic waste powder in concrete would benefit in many ways in saving energy protecting the environment. The cost of deposition of ceramic waste in landfills will be saved.Raw materials and natural resources will be replaced.

Get Price

(PDF) Use of Ceramic Waste Powder in Cement Concrete ...

IJIRST –International Journal for Innovative Research in Science Technology Volume 2 Issue 1 June 2015 ISSN (online): 2349-6010 Use of Ceramic Waste Powder in Cement Concrete Hardik Patel Dr. N.K. Arora Department of Structural Engineering Principle Darshan Institute of Engineering And Technology, Rajkot, Lukhdhirji Engineering Collage, Morbi, India India Shraddha R. Vaniya Assistant ...

Get Price

Recycling ceramic waste powder and its usage as an ...

Using ceramic waste powder (CWP) as an ingredient to partially replace cement in concrete will have a positive and progressive environmental impact in addition will help reserve natural resources. In this study, CWP material will be examined as a supplementary cementing

Get Price

Partial Replacement of Cement in Concrete using Ceramic

Dec 23, 2019  Ceramic waste powder can be used to produce lightweight concrete, without affecting. The compressive strength of concrete of the concrete improved by the use of optimal dosage of ceramic tile powder. Keywords:-Ceramic waste, properties of ceramic waste, partial replacement of cement. INTRODUCTION

Get Price

A Study on Ceramic Waste Powder

Ceramic Powder II. LITERATURE REVIEW Fine Amitkumar D. Raval, Indrajit N. Patel, Jayeshkumar Pitroda Use Of Ceramic Powder As A Partial Replacement Of Cement the OPC cement has been replaced by ceramic waste powder accordingly in the range of 0%, 10%, 20%, 30% 40%, 50% by weight for M-25 grade concrete. The Compressive

Get Price

(PDF) Eco-Efficient Concretes: Use Of Ceramic Powder As

Similarly, Raval et al. [12] described the use of ceramic waste powder as partial replacement of cement and found that the use of ceramic brickwork debris as active addition endows cement with ...

Get Price

Ceramic waste powder an alternative cement replacement ...

Sep 01, 2018  Senthamaria et al. 2011 , investigated the use of ceramic waste in concrete and concluded that it had potential to be used as a concrete ingredient but needs further investigations. Vejmelková et al. 2012 [ 7 ], replaced cement with ceramic waste (10, 20, 40 and 60% by mass).

Get Price

(PDF) CERAMIC WASTE: EFFECTIVE REPLACEMENT OF

In this research study the (OPC) cement has been replaced by ceramic waste powder accordingly in the range of 0%, 10%, 20%, 30% 40%, 50% by weight of M

Get Price

(PDF) The Use of Ceramic Tiles Waste in Concrete as ...

Evaluation of the use of ceramic waste powder as a partial replacement for cement with addition of polypropylene fibers in concrete showed that the compressive, split tensile and flexural strength of M30 grade concrete increased when the replacement of cement

Get Price

Ceramic Waste : Effective Replacement Of Cement For ...

50% of the cement is replaced with ceramic waste,the data from the ceramic waste is compared with data from a standard concrete without ceramic waste. Three cube samples were cast on the mould of size 150*150*150 mm for each 1:1.80:3.84 concrete mix with partial replacement of cement with a w/c ratio as 0.52 were also cast. After about 24 h the ...

Get Price

(PDF) use of ceramic waste in concrete: a review

So, what is done that the OPC cement is replaced with the waste of ceramic powder consequently in various stages: 0%, 15%, 20%, 25%, 30%, and 35% using grade M-20 weight of concrete.

Get Price

Recycling ceramic waste powder and its usage as an ...

Using ceramic waste powder (CWP) as an ingredient to partially replace cement in concrete will have a positive and progressive environmental impact in addition will help reserve natural resources. In this study, CWP material will be examined as a supplementary cementing

Get Price

Utilization of ceramic waste powder in cement mortar ...

Nov 26, 2020  The utilization of ceramic waste powder (CWP) is increasing in construction industry and influences significantly fresh and mechanical properties of concrete. However, these properties of concrete significantly changed if subjected to higher temperature. Thus, this paper presents the effect of partial replacement of cement to CWP with different weight percent (0%, 20%, 40% and 60%) on the ...

Get Price

(PDF) Eco-Efficient Concretes: Use Of Ceramic Powder As A ...

Similarly, Raval et al. [12] described the use of ceramic waste powder as partial replacement of cement and found that the use of ceramic brickwork debris as active addition endows cement with ...

Get Price

Partial Replacement of Cement in Concrete using Ceramic Waste

Dec 23, 2019  Ceramic waste powder can be used to produce lightweight concrete, without affecting. The compressive strength of concrete of the concrete improved by the use of optimal dosage of ceramic tile powder. Keywords:-Ceramic waste, properties of ceramic waste, partial replacement of cement. INTRODUCTION

Get Price

Partial Replacement of Cement in Concrete using Ceramic

forces. Ceramic waste powder can be used to produce lightweight concrete, without affecting. The compressive strength of concrete of the concrete improved by the use of optimal dosage of ceramic tile powder. Keywords:-Ceramic waste, properties of ceramic waste, partial replacement of cement. 1. INTRODUCTION

Get Price

(PDF) The Use of Ceramic Tiles Waste in Concrete as ...

Evaluation of the use of ceramic waste powder as a partial replacement for cement with addition of polypropylene fibers in concrete showed that the compressive, split tensile and flexural strength of M30 grade concrete increased when the replacement of cement

Get Price

Reuse of Ceramic Waste as Aggregate in Concrete

reuse of these ceramic wastes in concrete production could be an effective measure in maintaining the environment and improving the properties of concrete. In the present study, Ceramic tile waste were used in concrete as a replacement for natural coarse aggregate with 0%, 10%, 20% and 30% of the substitution and M20 grade concrete were used ...

Get Price

Waste glass powder as partial replacement of cement for ...

Jun 01, 2017  Trial mix design were conducted to obtain the target strength of 35 MPa at 28 days with a workability of 100–125 mm as per American Concrete Institute ACI 211.1 (ACI, 2009).The glass powder replacement in cement was varied (0–25%). Mix proportion of concrete is shown in Table 6.Firstly, stone chips and sand were dry mixed for a minute.

Get Price

Ceramic waste - SlideShare

Mar 30, 2016  Result In Ceramic Waste Different proportions of waste ceramic are use as course aggregate in cement concrete to determine the compressive strength. Compressive Strength Ceramic waste as aggregate Replace by 10% of aggregate 7 days test result 28 days test result Sample 1 - 620 KN Sample 2 - 600 KN Sample 3 - 605 KN

Get Price

Effect of Ground Waste Concrete Powder on Cement Properties

May 23, 2013  The amount of paste/mortar in waste concrete is about between 20% and 50%, but relative research is very limited [10–13]. Lv found that when waste concrete powder content is lower than 30%, its effect on cement strength is the same as fly ash’s and that its effect becomes more evident after heat treatment .

Get Price

High performance concrete incorporating ceramic waste ...

Ceramic waste powder (CWP) is produced during ceramic tile polishing with potential environmental pollution. CWP is silica-rich, alumina-rich and fine particle size material. High performance concrete (HPC) mixtures incorporating 10–40% CWP as replacement of

Get Price

powder uses in ceramic

Use of Ceramic Waste Powder in Cement Concrete. 2015-6-10 In the ceramic industry, about 15%-30% waste material generated from the total production. This waste is not recycled in any form at present. However, the ceramic waste is durable, hard and highly resistant to biological, chemical, and physical degradation forces.

Get Price

ceramic waste as coarse aggregates and quarry dust as fine

Strength of Concrete with Ceramic Waste and Quarry Dust Abstract This research focuses on a study of the strength of concrete with ceramic waste as coarse aggre. ... fly ash mill for cement raw materials; ... equipment for copra crushing plant in congo kinshasa; ceramic

Get Price

(PDF) use of ceramic waste in concrete: a review

So, what is done that the OPC cement is replaced with the waste of ceramic powder consequently in various stages: 0%, 15%, 20%, 25%, 30%, and 35% using grade M-20 weight of concrete.

Get Price

Utilization of ceramic waste powder in cement mortar ...

Nov 26, 2020  The utilization of ceramic waste powder (CWP) is increasing in construction industry and influences significantly fresh and mechanical properties of concrete. However, these properties of concrete significantly changed if subjected to higher temperature. Thus, this paper presents the effect of partial replacement of cement to CWP with different weight percent (0%, 20%, 40% and 60%) on the ...

Get Price

Reuse of Ceramic Waste as Aggregate in Concrete

reuse of these ceramic wastes in concrete production could be an effective measure in maintaining the environment and improving the properties of concrete. In the present study, Ceramic tile waste were used in concrete as a replacement for natural coarse aggregate with 0%, 10%, 20% and 30% of the substitution and M20 grade concrete were used ...

Get Price

(PDF) Reuse of Ceramic Waste as Aggregate in Concrete ...

Parmindar singh, “Utilization of waste ceramic tiles as aggregate in concrete” Journal of Graph – 4.2: M20 concrete grade with 0%, 10%, 20% and multidisciplinary engineering science and 30% replacement of CTA and their tensile strength at 3,7 technology (IJMEST), ISSN: 3159-0040 Vol 2 issue and 28 days 11, pp 3294-3300.

Get Price

Effect of ceramic waste powder as partial fine aggregate ...

Aswin et al 12 used ceramic waste powder (CWP) by 10%, 20%, 30%, 40%, and 50% replaced by weight of cement. The results showed an enhancement in compressive strength when a 40% of ceramic waste was used. Ramadevi 13 studied the concrete properties including ceramic waste with 0%, 25%, 50%, and 75% replaced by weight of fine aggregate. Results ...

Get Price

EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF

Therefore, utilization of the ceramic waste powder in various industrial sectors especially the construction, agriculture, glass and paper industries would help to protect the environment. In this research study the cement has been replaced by ceramic waste powder accordingly in the range of 10% 15%, 20% by weight of M30 grade.

Get Price

High performance concrete incorporating ceramic waste ...

Jul 30, 2017  Ceramic waste powder (CWP) is produced during ceramic tile polishing with potential environmental pollution. CWP is silica-rich, alumina-rich and fine particle size material. High performance concrete (HPC) mixtures incorporating 10–40% CWP as

Get Price

powder uses in ceramic

Use of Ceramic Waste Powder in Cement Concrete. 2015-6-10 In the ceramic industry, about 15%-30% waste material generated from the total production. This waste is not recycled in any form at present. However, the ceramic waste is durable, hard and highly resistant to biological, chemical, and physical degradation forces.

Get Price

Use of Tile Dust as Partial Replacemnt for Cement in Concrete

safe disposal of Ceramic waste. By adopting such methods we can overcome problems such as waste disposal crisis. K. Shyam Chamberlin. For 20% cement replacement with tile dust indicates saving of around 17% in the cost of Portland cement in concrete. The cost of cement represents almost 45% of the concrete cost. Therefore, overall cost

Get Price

Use of Waste Marble Powder as Partial Replacement in ...

main objective of this study is to develop useful concrete mixes using waste marble powder as partial replacement of cement and sand. Keywords: Waste marble powder, concrete, compressive strength, flexure strength, split-tensile strength, workability, durability. I. INTRODUCTION. Marble is obtained from the transformation of pure limestone.

Get Price

EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF

variation of strength of hardened concrete using ceramic waste powder as partial replacement of cement and coconut shells as a partial replacement to coarse aggregate is studied by casting 3 cubes, 3 cylinders and 3 prisms for each and replacement. The specimens were tested for period of 7days, 28 days, 56 days and 90 days as per the mix design.

Get Price

ceramic waste as coarse aggregates and quarry dust as fine

Strength of Concrete with Ceramic Waste and Quarry Dust Abstract This research focuses on a study of the strength of concrete with ceramic waste as coarse aggre. ... fly ash mill for cement raw materials; ... equipment for copra crushing plant in congo kinshasa; ceramic

Get Price

Comparison of pozzolanic properties of ground ceramic ...

However, the replacement of cement by ceramic waste decreases the mechanical strength, which may be associated with the immature pozzolanic reaction, affected by non-hydraulic ceramic powder ...

Get Price

(PDF) DURABILITY ASPECTS OF CONCRETE BY PARTIAL ...

Ceramic waste is one of the most active research areas that hold within a number of regulations including civil engineering and construction materials. Ceramic waste powder is settled by alleviation and then dumped away which results in environmental

Get Price
Copyright © 2021.Cina QC All rights reserved.Cina QC